Recent Advances and Challenges of Small-Capacity Air-Cooled Solar-Assisted Ammonia Absorption Chillers in Tropical Regions
DOI:
https://doi.org/10.31004/joecy.v6i1.8232Keywords:
Absorption chiller, Ammonia-water, Solar energy, Air-cooled, Tropical climatesAbstract
The rapidly increasing demand for air conditioning has intensified energy consumption, environmental impacts, and water use associated with conventional vapor compression cooling systems. Solar-powered absorption chillers offer a low-carbon alternative by utilizing renewable thermal energy and environmentally friendly working fluids. This paper presents a literature review on the development of solar-powered absorption chiller systems, with a focus on small-capacity, air-cooled chillers using ammonia as the working fluid. The review is structured chronologically, covering early feasibility studies through performance improvement, compact system design, and adaptation to hot and tropical climates. Compared to water-cooled systems, air-cooled configurations eliminate the use of cooling towers, thereby reducing water consumption and enabling simpler system designs, although they face challenges in heat rejection under high ambient temperatures. Ammonia–water systems show strong potential due to their high temperature tolerance, zero Global Warming Potential, and suitability for air-cooled operation. This review identifies key technological advances, major limitations, and important research gaps, particularly for applications in tropical regions such as Indonesia.
References
B. Pandya, V. Kumar, V. Matawala, and J. Patel, “Thermal comparison and multi-objective optimization of single-stage aqua-ammonia absorption cooling system powered by different solar collectors,” J Therm Anal Calorim, vol. 133, no. 3, pp. 1635–1648, 2018, doi: 10.1007/s10973-018-7193-z.
A. Al-Falahi, F. Alobaid, and B. Epple, “Thermo-Economic Comparisons of Environmentally Friendly Solar Assisted Absorption Air Conditioning Systems,” Applied Sciences, vol. 11, no. 5, 2021, doi: 10.3390/app11052442.
M. M. A. Khan, N. I. Ibrahim, R. Saidur, I. M. Mahbubul, and F. A. Al-Sulaiman, “Performance assessment of a solar powered ammonia–water absorption refrigeration system with storage units,” Energy Convers Manag, vol. 126, pp. 316–328, 2016, doi: https://doi.org/10.1016/j.enconman.2016.08.004.
D. S. Ayou and A. Coronas, “New Developments and Progress in Absorption Chillers for Solar Cooling Applications,” Applied Sciences, vol. 10, no. 12, 2020, doi: 10.3390/app10124073.
M. I. Alhamid, Nasruddin, A. Lubis, K. Saito, H. Yabase, and N. Aisyah, “Energy Analysis for the Solar Thermal Cooling System in Universitas Indonesia,” International Journal of Air-Conditioning and Refrigeration, vol. 27, no. 03, p. 1950023, Jun. 2019, doi: 10.1142/S2010132519500238.
D. Agung, G. G. Genta, A. Lubis, M. I. Alhamid, and N. Nasruddin, “Development of Key Components for 5 kW Ammonia–Water Absorption Chiller with Air-Cooled Absorber and Condenser,” Energies (Basel), vol. 17, no. 17, Sep. 2024, doi: 10.3390/en17174376.
P. Soto and W. Rivera, “Experimental assessment of an air-cooled absorption cooling system,” Appl Therm Eng, vol. 155, pp. 147–156, 2019, doi: https://doi.org/10.1016/j.applthermaleng.2019.03.104.
A. Al-Falahi, F. Alobaid, and B. Epple, “Thermo-economic evaluation of aqua-ammonia solar absorption air conditioning system integrated with various collector types,” Entropy, vol. 22, no. 10, pp. 1–29, Oct. 2020, doi: 10.3390/e22101165.
A. A. S. Lima et al., “Absorption Refrigeration Systems Based on Ammonia as Refrigerant Using Different Absorbents: Review and Applications,” Energies (Basel), vol. 14, no. 1, 2021, doi: 10.3390/en14010048.
M. Xu, S. Li, Z. Jin, W. Jiang, and K. Du, “The influence of NH3-H2O-LiBr ternary working fluid on the performance and solution circulation in ammonia absorption refrigeration system,” Appl Therm Eng, vol. 234, p. 121297, 2023, doi: https://doi.org/10.1016/j.applthermaleng.2023.121297.
A. Ghafoor and A. Munir, “Worldwide overview of solar thermal cooling technologies,” Renewable and Sustainable Energy Reviews, vol. 43, pp. 763–774, 2015, doi: https://doi.org/10.1016/j.rser.2014.11.073.
A. Aliane, S. Abboudi, C. Seladji, and B. Guendouz, “An illustrated review on solar absorption cooling experimental studies,” Renewable and Sustainable Energy Reviews, vol. 65, pp. 443–458, 2016, doi: https://doi.org/10.1016/j.rser.2016.07.012.
D. N. Nkwetta and J. Sandercock, “A state-of-the-art review of solar air-conditioning systems,” Renewable and Sustainable Energy Reviews, vol. 60, pp. 1351–1366, 2016, doi: https://doi.org/10.1016/j.rser.2016.03.010.
H. Sheikhani et al., “A review of solar absorption cooling systems combined with various auxiliary energy devices,” J Therm Anal Calorim, vol. 134, no. 3, pp. 2197–2212, 2018, doi: 10.1007/s10973-018-7423-4.
P. S. Arshi Banu and N. M. Sudharsan, “Review of water based vapour absorption cooling systems using thermodynamic analysis,” Renewable and Sustainable Energy Reviews, vol. 82, pp. 3750–3761, 2018, doi: https://doi.org/10.1016/j.rser.2017.10.092.
A. A. Mustafa, Z. Noranai, and A. A. Imran, “SOLAR ABSORPTION COOLING SYSTEMS: A REVIEW,” Journal of Thermal Engineering, vol. 7, no. 4, pp. 970–983, 2021, doi: 10.18186/thermal.931165.
S. K. Tyagı1, A. Verma, and S. C. Kaushık, “Performance enhancement of absorption refrigeration systems: An overview,” Journal of Thermal Engineering, vol. 9, no. 4, pp. 1100–1113, 2023, doi: 10.18186/thermal.1334225.
S. K. Tyagi, S. C. Kaushik, and A. Verma, “Advances in solar absorption cooling systems: An overview,” Journal of Thermal Engineering, vol. 10, no. 4, pp. 1044–1067, 2024, [Online]. Available: https://dergipark.org.tr/en/pub/thermal/article/1518217
Abdelsalam Abdelwanes, Peter King, KGU Wijayantha, Kumar Patchigolla, and Renaldi Renaldi, “A review of solar absorption chillers and thermal storage by phase change materials,” Proceedings of the Institution of Mechanical Engineers, Part A: Journal of Power and Energy, p. 09576509251403068, Nov. 2025, doi: 10.1177/09576509251403068.
E. Bellos, I. Chatzovoulos, and C. Tzivanidis, “Yearly investigation of a solar-driven absorption refrigeration system with ammonia-water absorption pair,” Thermal Science and Engineering Progress, vol. 23, p. 100885, 2021.
D. Ali and W. Ratismith, “A semicircular trough solar collector for air-conditioning system using a single effect NH3–H2O absorption chiller,” Energy, vol. 215, p. 119073, 2021.
S. Zhou, G. He, Y. Li, X. Liang, Q. Pang, and D. Cai, “Comprehensive experimental evaluation of an exhaust-heat-driven absorption refrigeration cycle system using NH3-NaSCN as working pair,” International Journal of refrigeration, vol. 126, pp. 168–180, 2021.
A. Zapata, C. Amaris, A. Sagastume, and A. Rodriguez, “CFD modelling of the ammonia vapour absorption in a tubular bubble absorber with NH3/LiNO3,” Case Studies in Thermal Engineering, vol. 27, p. 101311, 2021.
A. Al-Falahi, F. Alobaid, and B. Epple, “Thermo-economic comparisons of environmentally friendly solar assisted absorption air conditioning systems,” Applied Sciences, vol. 11, no. 5, p. 2442, 2021.
X. Tao, D. Thanganadar, and K. Patchigolla, “Compact ammonia/water absorption chiller of different cycle configurations: parametric analysis based on heat transfer performance,” Energies (Basel), vol. 15, no. 18, p. 6511, 2022.
S. Braccio, H. T. Phan, M. Wirtz, N. Tauveron, and N. Le Pierres, “Simulation of an ammonia-water absorption cycle using exchanger effectiveness,” Appl Therm Eng, vol. 213, p. 118712, 2022.
Mathilde Wirtz, “Spécialité : Énergétique et Génie des Procédés Mathilde WIRTZ Thèse dirigée par Benoit STUTZ Development of a falling-film desorber combining vapor generation and purification for ammonia-water absorption chiller (Modeling and Experiments),” 2022.
S. A. Boltaev, K. S. Akhmadov, U. R. Gapparov, R. Djabbarganov, M. K. Kurbanov, and D. S. Saidov, “Thermotechnical and adsorption characteristics of the SrCl2 adsorbent for ammonia vapors in solar absorption cycles,” Applied Solar Energy, vol. 58, no. 1, pp. 116–120, 2022.
O. May Tzuc et al., “Multivariate inverse artificial neural network to analyze and improve the mass transfer of ammonia in a Plate Heat Exchanger-Type Absorber with NH3/H2O for solar cooling applications,” Energy Exploration & Exploitation, vol. 40, no. 6, pp. 1686–1711, 2022.
C. Amaris, A. Rodriguez, A. Sagastume, and M. Bourouis, “Performance assessment of a solar/gas driven NH3/LINO3 absorption cooling system for malls,” in Recent Advances in Energy Technologies: Select Proceedings of ICEMT 2021, Springer, 2022, pp. 311–328.
M. E. Palacios-Lorenzo and J. D. Marcos, “Downsizing strategy for an air-cooled indirect-fired single-effect ammonia-water absorption chiller in part-load operation in hot climates,” Case Studies in Thermal Engineering, vol. 53, p. 103911, 2024.
Y. Li, Y. Li, H. Zhang, W. Zheng, and J. Wang, “Thermodynamic analysis of a hybrid ammonia-water refrigeration cycle with low-temperature solar heat,” Appl Therm Eng, vol. 253, p. 123791, 2024.
M. El Amine Chikh, M. Benramdanex, M. Benramdane, A. Aliane, and B. Abdesselam, “Impact of Ammonia-water Concentrations on Solar Absorption Refrigeration Performance.,” Renewable Energy & Sustainable Development, vol. 11, no. 1, 2025.
A. Márquez-Nolasco, S. L. Pérez-García, and A. J. García-Cuéllar, “Energy Performance Evaluation of an Ammonia–Water Absorption Chiller for Varying Operating Conditions,” Processes, vol. 13, no. 12, p. 3790, 2025.
I. Boukholda, N. Ben Ezzine, and A. Bellagi, “Experimental investigation and simulation of commercial absorption chiller using natural refrigerant R717 and powered by Fresnel solar collector,” International Journal of Thermofluids, vol. 27, p. 101213, 2025.
S. Zhou, G. He, W. Sun, M. Fan, D. Wang, and Q. Song, “Flow boiling heat transfer characteristic of NH3/LiNO3+ H2O absorption refrigeration working fluid in horizontal tubes: A comprehensive experimental evaluation and comparison,” Int J Heat Mass Transf, vol. 245, p. 127018, 2025.
V. K. Pham, N. Le Pierrès, and H. T. Phan, “Overview of Research on NH3-H2O Absorption Heat Pump and Refrigeration Cycles Including Generator/Absorber Heat-Exchangers,” Heat Transfer Engineering, pp. 1–28, 2025.
N. Maninggar, P. B. B. Sutanty, T. J. G. Henares, and M. Uchiyama, “Beating the Heat: Policy Recommendations for Kampung Cooling Infrastructure in Surabaya”.
K. N. Handayani, S. Murtyas, A. T. Wijayanta, and A. Hagishima, “Thermal Comfort Challenges in Home-Based Enterprises: A Field Study from Surakarta’s Urban Low-Cost Housing in a Tropical Climate,” Sustainability, vol. 16, no. 16, 2024, doi: 10.3390/su16166838.
K. Miyamoto, S. N. Pratiwi, S. Nishiiri, H. Takaguchi, and T. Kubota, “Relationship between Cooling Methods and Energy Consumption for the Development of Low-Carbon Collective Housing in Indonesia,” Sustainability, vol. 16, no. 4, p. 1635, 2024.
R. P. Pradana et al., “Assessing Green Strategies for Urban Cooling in the Development of Nusantara Capital City, Indonesia,” Climate, vol. 13, no. 2, p. 30, 2025.
J.-H. J. Kim et al., “Phase II Cost-Benefit Analysis: Economic Impact Assessment For Indonesia Building Sector Whole-Building Cooling Solutions,” Argonne National Laboratory (ANL), Argonne, IL (United States); Lawrence …, 2023.
R. T. Muehleisen et al., “Cost-Benefit Analysis For Indonesia Building Sector: Whole-Building Cooling Solutions,” Lawrence Berkeley National Laboratory (LBNL), Berkeley, CA (United States …, 2024.
C. Szum and R. Levinson, “Cost-Benefit Analysis For Indonesia Building Sector: Whole-Building Cooling Solutions,” 2024.
F. Farizal, M. A. Noviandri, and H. Hamdani, “Sustainability Development through a Nearly Zero Energy Building Implementation Case: An Office Building in South Jakarta,” Sustainability, vol. 16, no. 16, 2024, doi: 10.3390/su16167027.
D. M. Fasya, S. Song, and S. Yoon, “Assessing the potential of hybrid cooling systems for energy efficiency in tropical mid-rise office building under Jakarta’s climate condition,” IOP Conf Ser Earth Environ Sci, vol. 1574, no. 1, p. 012024, 2025, doi: 10.1088/1755-1315/1574/1/012024.
F. Yudhi, M. I. Alhamid, N. Putra, and A. Lubis, “A study on temperature, relative humidity, and energy consumption in long-distance trains air conditioning systems in Indonesia,” Case Studies in Thermal Engineering, p. 106122, 2025.
H. Dipocaksono, R. Setiawan, and J. Hendrarsakti, “Preliminary Design and Local Component Sourcing of Electric Vehicle Cooling System,” in 2025 8th International Conference on Electric Vehicular Technology (ICEVT), IEEE, 2025, pp. 233–239.
R. Darussalam et al., “PV cooling system preferences based on PV module temperature in Indonesia,” in AIP Conference Proceedings, AIP Publishing LLC, 2024, p. 020112.
F. A. Hidayat et al., “A Solar Distillation Prototype With Cooling Fan and External Solar Collector for Clean Water Supply: Steps Towards Sustainable Development Goals (Sdgs),” Journal of Engineering Science and Technology, vol. 19, no. 5, pp. 27–34, 2024.
S. Herawati et al., “Optimizing cold chain logistics for bio fortified crops,” in BIO Web of Conferences, EDP Sciences, 2025, p. 02003.
R. B. Tri Joko Wibowo and E. Anggraeni, “SUSTAINABLE COLD SUPPLY CHAIN MANAGEMENT OF TUNA AGRO-INDUSTRY: A SYSTEMATIC LITERATURE REVIEW AND FUTURE RESEARCH.,” Indonesian Fisheries Processing Journal/Jurnal Pengolahan Hasil Perikanan Indonesia, vol. 27, no. 9, 2024.
F. BASBETH, S. H. WISUDO, and M. IMRON, “Moving Towards a Successful Cooperative: The Significance of Cold Chain Logistics,” Transformations in Business: Case Studies on Governance, Economics, Finance, Performance, Logistics, and Sustainability for the Future, p. 55.
E. Purwanto, Y. Iskandar, and P. Bhaktiar, “A bibliometric analysis on energy efficiency and conservation,” in E3S Web of Conferences, EDP Sciences, 2024, p. 03001.
I. Kusuma, R. Ruliyanta, D. Widiastuti, and M. Fathoni, “Optimizing electrical energy savings by utilizing refrigerant catalysts in compressors,” Przegląd Elektrotechniczny, vol. 100, 2024.
A. M. A. Setiawan, S. Permana, and T. Setiadipura, “Study of Prospecting NPP Cogeneration as District Heating and Cooling in Indonesia,” in IOP Conference Series: Materials Science and Engineering, IOP Publishing, 2025, p. 012007.
Downloads
Published
How to Cite
Issue
Section
License
Copyright (c) 2026 Desy Agung, Siti Astari Pratiwi, Adinda Rahmah Shalihah
This work is licensed under a Creative Commons Attribution-ShareAlike 4.0 International License.
